Independent EV repair
Tesla & EV repair in Sharjah
Electric car repair and service in Industrial Area 11, Sharjah: drive units, AC and heat pumps, cooling, HV battery and power electronics, suspension, 12V/16V batteries and software, for Tesla, VW ID., BYD and hybrids. An independent garage, open Saturday to Thursday, with pickup and drop-off on request.
System map
What we work on, system by system
A generic electric-car layout. Pick a system to see the jobs we do on it.
Illustration: a generic electric-car chassis seen from above, not any particular make or model.
Pick a system
Tap a numbered system on the drawing or in the list to see the work we do on it, then message us about it.
System 1
Drive unit & motor
Motor bushes, drive-unit isolation faults and drive-unit oil.
Common symptoms
- A clunk from the rear when you accelerate or lift off
- A drive-unit or isolation warning on the screen
What we check
- Noise on a road test and on the lift
- Motor mounts and bushes
- Isolation readings and fault codes
What we do
- Motor bush replacement
- Drive-unit isolation repair
- Drive-unit oil service
System 2
HV battery & power electronics
Contactors, PCS and pyro fuse replacement, with the programming the car needs. Recall work is free at the manufacturer: check your VIN first.
Common symptoms
- The car will not go into drive after a warning
- Charging stops or the charge port shows a fault
What we check
- High-voltage warnings and fault codes
- Contactor and PCS operation
What we do
- Contactor replacement
- PCS replacement
- Pyro fuse replacement
- Programming after the repair
System 3
Cooling & radiator
Radiator deep cleaning or replacement, coolant flush and water pumps.
Common symptoms
- A coolant or fan warning in summer heat
- The fans run loudly for a long time after a drive
What we check
- Radiator and condenser condition
- Coolant level, leaks and pump operation
What we do
- Radiator deep cleaning
- Radiator replacement
- Coolant flush
- Water pump replacement
System 4
AC & heat pump
Compressor, condenser, cabin filters, gas refill and system flushing.
Common symptoms
- The AC blows warm air
- A musty smell from the vents
What we check
- Refrigerant pressure and leaks
- Compressor and condenser operation
What we do
- Compressor replacement
- Condenser replacement
- Cabin filter replacement
- Gas refill and system flushing
System 5
Suspension & steering
Control arms, links, knuckles, bushes and steering racks.
Common symptoms
- Knocking over bumps
- The steering feels loose or pulls to one side
What we check
- Play in the arms, links and bushes on the lift
- Steering rack and tie rods
What we do
- Control arms and links
- Knuckles and bushes
- Steering rack
System 6
12V / 16V battery
Low-voltage battery replacement, reset and configuration.
Common symptoms
- A 12V or low-voltage battery alert
- The car will not wake up or unlock
What we check
- Battery health and charging from the car
What we do
- 12V / 16V battery replacement
- Reset and configuration
- Battery unlock where the car needs it
System 7
Software & programming
Software updates on VW ID. models, and the programming a car needs after high-voltage repairs.
Common symptoms
- An update is needed or failed
- A warning message you cannot clear
What we check
- Fault codes and module software versions
What we do
- Software updates on the VW ID.4 and ID.6
- Programming after high-voltage repairs
- Diagnosis of warning messages
Start here
Scheduled service & inspection
Minor and major services and standard inspections for electric cars.
What we do
- Minor and major service
- Standard inspection
Symptom checker
What is your car doing?
Pick what you notice. We’ll show the system it is often related to and what to send us. Only a check at the workshop can confirm the cause.
- The AC blows warm air Often related to AC & heat pump
- A clunk from the rear over bumps Often related to Suspension & steering
- A clunk from the rear when you accelerate or lift off Often related to Drive unit & motor
- A whine or hum from the rear motor Often related to Drive unit & motor
- A knock from the steering when you turn Often related to Suspension & steering
- A 12V or 16V battery warning Often related to 12V / 16V battery
- The car won’t wake up or unlock Often related to 12V / 16V battery
- The car won’t charge Often related to HV battery & power electronics
- A coolant or cooling-system warning Often related to Cooling & radiator
- The fans run loudly for a long time after a drive Often related to Cooling & radiator
- A software update failed or keeps asking to install Often related to Software & programming
- A warning message that won’t clear Often related to Software & programming
Services
What we repair
The jobs below are the work our workshop does on electric cars. Each page explains what the work involves. Recall repairs are free at the manufacturer, so check your VIN with them first.
- Drive unit & motor repair Motor bush replacement, drive-unit isolation faults and drive-unit oil service.
- AC & heat pump repair Compressor and condenser replacement, cabin filters, gas refill and flushing.
- Cooling & radiator cleaning Radiator deep cleaning or replacement, coolant flush and water pump replacement.
- HV battery & power electronics Contactor, PCS and pyro fuse replacement, with the programming the car needs afterwards.
- Suspension & steering Control arms, links, knuckles, bushes and steering rack repairs.
- 12V / 16V battery Low-voltage battery replacement, reset and configuration.
- Software updates & programming Software updates for the VW ID.4 and ID.6, and module programming after repairs.
- Scheduled service & inspection Minor and major services and standard inspections for electric cars.
- EV diagnostics Warning lights, error messages and intermittent faults.
- Brake service Brake disc skimming on the lathe, and brake checks.
- Hybrid car repair Hybrid battery, inverter cooling, 12V, AC, brakes and routine service for hybrids of all makes.
- Pre-purchase inspection A full check of a used EV before you pay, with a written report.
- Battery health check State of health, cell balance, temperatures, insulation and stored alerts, with a written report.
- Company fleets Company accounts with monthly invoicing, priority booking, and pickup and drop-off.
Visit
Find us in Industrial Area 11
Opening hours, directions, and what our customers say on Google. Coming from Dubai or Abu Dhabi? See EV repair for Dubai and Abu Dhabi owners.
Getting here
Sat–Thu 08:00–19:00
- Address
- 18 St, Industrial Area 11, Sharjah, UAE Plus code: 7CWG+3Q Sharjah
- Opening hours
- Sat–Thu 08:00–19:00 Closed on Friday
How we work
From first message to handover
-
Message us
Send your car's model and year and what you are noticing on WhatsApp. A photo or short video of any warning helps.
-
Bring the car in
Come to the workshop in Industrial Area 11, Sharjah, during opening hours, or ask us on WhatsApp to collect the car and bring it back when the work is done.
-
Diagnosis, explained
We check the car, explain what we found, and send you a written quote on WhatsApp with the parts, labour and any programming the car needs. Nothing starts until you approve it.
-
Handover
When you collect the car, we walk you through what was done.
Questions about your Tesla, VW ID. or BYD?
Send the model, year and what you notice on WhatsApp. We reply during opening hours.